David Stevens Motor Engineers
Service Schedule
Initial Checks
Check vehicle history, customer comments and recommendations
Check for damage to bodywork, trims, lamps, number plates, mirrors etc
Check timing belt interval
Vehicle on the ground
Check ABS, all interior warning lights and horn
Check operation of interior and exterior lights and switches
Check front and rear windscreen wipers and washers
Check condition and security of windscreen and rear view mirror
Check fuel cap
Check air conditioning
Check & top up power steering reservoir
Check PAS, auxiliary and fan belts
Check pollen/cabin filter
Check battery condition and security
Check clutch operation
Check handbrake operation and travel
Check and top up all under bonnet fluid levels
Check and top up brake fluid
Check and top up anti-freeze
Check and top up clutch fluid
Lubricate door hinges, catches and locks (where required)
Check coolant system for leaks
Check engine cooling fan
Check operation of throttle and lubricate as required
Replace air filter
Replace fuel filter (diesel engines)
Replace spark plugs if applicable (at extra cost)
Visually inspect condition of HT leads
Vehicle raised / off the ground
Carry out under body inspection (check for any corrosion)
Replace engine oil (special or long life oils at extra charge)
Replace oil filter
Check exhaust system for security and leaks
Check security of fuel lines, brake pipes, hoses and handbrake cables visually
Check condition of distributor cap
Check engine and gearbox mounts for wear
Test starter motor cranking operation and security
Visually inspect radiator and coolant pipes/hoses for security and leaks
Check all wheel bearings for noise / free play
Check & record brake pads/shoes for condition & operation
Check & record drums and discs for condition and operation
Remove wheels & check condition and operation of front and rear brakes
Refit wheels (if applicable) / set wheel nut torque
Extra checks as per manufacturer schedule
Final checks
Carry out road test
Check exhaust emissions and idle speed
Re-set service light (most models)
Stamp customer’s service book
Interim Full
Any additional items/work is subject to additional charge
3 Grange Road, Egham,Surrey, TW20 9QW
Tel: 01784 433196
Check condition and operation of all seatbelts
Check and top up gearbox oil/axel oil/transfer box oil (if applicable)
Check condition and security of steering, suspension, mountings and gaitors
Check for signs of leakage from cylinders / callipers (if applicable)
Check condition of tyres and adjust tyre pressures (if required)
David Stevens Auto Engineers
Rear of 3 Grange Road,Egham,Surrey,TE20 9QW
Telephone:01784 433196
Mobile:      07867 884474
Fax:           01784 438769